Tuesday, September 29, 2015

The $320 1 Hour Van Conversion

Storage might also go to the right here instead of stool.

After the interest in my $800 1 Week No Skill Van Conversion, I got me thinking that there are more people out there who might be looking for an even faster, and less expensive, van conversion to get them on the road.   Most people like to get started, and then upgrade their space as they find out more about what things work best for them.   On forums, I see people burning a lot of time and money, or constantly struggling to save up the knot of cash for their dream conversion, only to find out they need to scrap it later as they figure out what they actually need.

So why bother?   You can spend a very small amount of money and get out on the road or more importantly, out from under your house bills.  Ill show you how to do it in less than a single hour (delivery times not withstanding, though with amazon prime it would only take 2 days) and less than a paycheck.

To be happy in this life style (and not quitting because you are miserable), at the very least you need a comfortable bed, a way to cook, a way to go potty, some light, and organization.   Ill break down each of these.

As with the previous No Skill Conversion,  you won't need any tools or prior knowledge.  Ill try to keep prices current and the cheapest option listed, so check back for updates if you have to.  I've tested all these items for min. 2 weeks (often longer), or a very similar item (since i may update with a better/cheaper alternative).

If you would like to see a video of this conversion instead, stay tuned!  (or better yet, subscribe to my youtube channel and get notified when it drops! :))

Sleep

Don't mind the hole in the wall...

 The best mattress I have found for the money is the $144.00 Signature Sleep 8-Inch Memory Foam Mattress, Twin from Amazon.  I've used this mattress for 2 years now, and it has held up exceptionally well.   I am a very large man, and I still don't bottom out on it.

So easy!

For the frame I selected the $59.99 Sleep Master SmartBase Mattress Bed Frame from walmart. It is available from amazon if you need it delivered but its about 40 dollars cheaper through walmart.  This bedframe is very light and assembles in about 2 minutes, you have to tighten 4 wing nuts with your fingers and you are done. 
I ordered and used this for 2 weeks, just for you!

I was shocked at just how simple it was, and it has worked very well in my 2 week test.  Some reviewers complained of noise, but I have not noticed an abundance, certainly not as much as some box springs I have owned.
Still some room under and beside the bed.

Cooking

Everything you need, in a tiny package

I've had this idea for a kitchen galley for a long time.   Kitchen cabinets/counters can be very expensive, and very difficult to build yourself if you don't have the tools or know-how.   I solved this problem with $19.99 Whitmor 6256-978 Storage Cubes.  These little metal wire storage cubes are pretty neat, they use plastic connectors to assemble (just squeeze them on) and so you can customize the configuration to what you like.  I chose the 4 cube set (kids set is same as regular, but cheaper, its just multicolored).  Each cube is 15 inches.

Update:  If you can get milk crates free or cheaper, they can be used the same way, zip tied together.

Assembled, and ready, takes minutes and elbow grease.

You can leave the front side of a cube open for front access, or the top off to reach down in.  The wire structure is very handy in general, you can clip bungees, caribiners, and items right to it.  You can also make it even more secure with zip ties at the connections.

Its not a fridge but it will work...

The left cube I left the top off, to drop a $12.34 Rubbermaid 10 qt. Cooler inside.   This allows me to open it from the top easily.   The right cube has a top but the front face is left off, and an $17.95 Reliance Products Aqua-Tainer 7 Gallon Rigid Water Container slides inside for our faucet.   Secure it with a bungee.   Ive driven this down ridiculously rough roads to test it, and despite the weight (and a slight bow to the cube bottom) it holds up fine even without zip ties, but if filling it i would use them.  This video explains further.


Don't fill all the way if you can help it, heavy!

The sink is a simple dish pan from the local dollar store, not gonna bother linking it, just slide it in the cube beneath :)  Pull the pan out under the faucet to catch water, remove the pan completely to toss grey water out.  This is a good place to store dishes and frying pan/pot too.  I also store some personal hygiene stuff here too, so its a bathroom sink and kitchen sink. 

The last cube you can leave the front off and stick food inside, or if you want to spend an extra 6 dollars get a cloth cube drawer as pictured here.

Surprising amount of food in there

Although you can do most of your cooking over the campfire, some times you might be restricted from doing so.  For a stove I chose the smallest and cheapest type, a butane stove.  They are pretty much all very similar, so the $17.77 Coleman Butane Instastart Stove is fine.

Free!  Cut to fit.

Since these have little feet on em, I decided to cover the top right cube with corrugated plastic, which conveniently slots into the cubes plastic connectors.  You can get this plastic for free, gas station signs (ask first!) and tons of election signs (after election) are made from them, just cut them and use the white side.

I tested cooking inside with this setup.   A word of caution, as with any flame you need to have ventilation and adequate space around and above it.   I have a roof vent that works, but since the stove is far from it and my van has a low ceiling, I have to keep an eye on it.  I left the stove running for a while with nothing on it, and the paneling above was too hot to touch after about 10 minutes.   So better to move the stove where it has ample room above it (floor or outside) or limit cooking times to a short duration.  You might notice the fire extinguisher, I also have a carbon monoxide detector, and a wool fire blanket.

I strap the stove to the cube top with another bungee for transport.
 Moving the stove also provides a small counter, or just use the top of the cooler :)

Organization

Little drawers, 3 small baskets, clothes, and still more space.

Under the bed is plenty of room for storage.   It may be a little tough to get to, as you dont have much room left beside the bed frame to pull stuff out.   I used several small containers I had on hand already and stuck them under in various ways, it worked out well.   I think for clothing storage, $12.99 Whitmor Underbed Storage Bags, Berry Blue, Set of 2 will work good.   Each one should fit between the legs, and can be partially pulled out to get access.  Of course with the bedframe, you can lift the bed up and reach through the frame too, one of the benefits of not having to have a box spring.
Lots of storage back here, over/around the wheel well.

For the other organization aspects, just work in baskets and smaller containers where needed.  If you can squeeze it in there, a $17 dollar 3 drawer unit from wally world might work (in this setup, id put it against the curtain up front behind passenger seat where i originally had the cubes if i didnt want a chair/stool).   Since the bed frame unfortunately does not fit over the wheel wells, you can still use that space behind the bed to great effect.   Throw long storage items back there like duffel bag for dirty clothes, folding camp chair, tire change gear, tent etc.

Potty/Bath

Not much to say...
 $19.99 Reliance Products Luggable Loo Portable 5 Gallon Toilet does the trick and its the cheapest, beyond just using public restrooms (recommended).   A lot of reviews and info on this out there, so not gonna rehash.  You can find lots of cheap or free showers out there, use your sink for a "bird bath", or if you want to spend a little more grab a $10 solar shower.

Light

Easy to overlook, but it just takes one night to realize you need it.   I keep a ton of cheap led flashlights on hand (check the tractor supply store bargain bin), but tap lights are a great way to have more 'permanent' house lighting.  The $7.04 Fulcrum 30010-301 LED Battery-Operated Stick-On Tap Light, Silver, 3 Pack, should do fine, stick one near the front, on the ceiling above the bed right in the middle of van, and one a back door.

Thats it!

This should come out to right around 320 dollars.  Some carpet from walmart ($20) and privacy curtains ($12) could tie it together. Of course you can add on or modify this forever by spending a little more (on electrical system for instance...) or even a little less (a good air mattress might save some cash....), but I hope that this conversion will provide a fast, inexpensive base to build your van dwelling life on.

Got a better idea for a really inexpensive van conversion?   Let me know in the comments.   Any questions as well.   Thanks for reading!   Next up....my real van conversion build out ;)

PS:  I think another good alternative to the cube galley is a desk (which i mention in the other conversion), which can serve its intended function and the role of kitchen counter and food storage.   However, it costs a little more for a walmart or ikea desk, which is junk in the long run (painted particle board).   I speak from experience, after a while it falls apart.  A nicer built desk would work good, but cost ya.

PPS: Also, if your in cold weather, and unable to move with the seasons, a Mr Buddy heater and insulation are a must.

Monday, September 7, 2015

Holding Pattern

Egg In Clamp, courtesy of freepik

Well i left my job on the 20th of august, and i have kind of been stuck in limbo at my sisters house.  Before I can complete my conversion and prepare to hit the road, I'm waiting for my 401k to cash out.  This normally wouldn't take long at all, if my employer would actually submit the paperwork to the company that handles it.   I submitted long before I left work, and he promised to forward it on my last day.  Since my employer is the 'plan administrator' as well, i need his approval on the paperwork (how this isn't a conflict of interest is beyond me...)

 But he has not so far, and there isn't much I can do about it.   I don't know if this is some sort of payback for leaving or what, but as my small amount of funds dwindles I may have to go right back to work again and all my plans will be changed.  This is pretty depressing for me.

I looked up my options from a legal standpoint, and for some reason the gov decided that for 'administrative purposes' they can drag this out to February, minimum, if they want to do so.   Its my money, which is dwindling every day it sits there as the market drops.  All i can do is hope they will do the decent thing and submit my paper work.

I guess if there is a silver lining, I am getting the opportunity to really see how far i can stretch my dollar this way.